Specification

Battery Type—2 x AGM  100Aph~~~
Supplied by
SUPAC
Gellideg Industrial Estate.
Maesycwmmer,
Mid Glamorgan
CF82 7SH
Tel:- 01443 815748
Warranty—Purchased 03.11.2008.
But has not been used
Battery Chargers. Mobitroni        The external charger sockets are for a 12 volt 8/10 amp Automatic type charger.
At rear each side of unit 2 sockets to charge batteries separately.
Wheels:--
Standel Dawman Ltd
Pasture Lane Works
Barrowford
Nelson Lancs BB9 6ES
Tel: 01282 613175           
www.standeldawman.uk.com/
Electronics Controller:--
4QD- 200 Series 36v  200amp Fully Protected
Supplier---- 4QD
30 Reach road
Burnwell Cambridgeshire CB5 0AH
Tel No 01638 741930 www.4QD.co.uk

[1]Motors:-- 2 x 24v 500 watt motors
[2]Gearboxes :--
Right & Left Auto Electric Brake not required
Supplier of 1 & 2 :---
EMD
Electric Motor Developments [Halstead] Ltd
Halstead Essex CO9 1HZ Tel No 01787 473461

Length:

56''  1400mm

Height:

58"  1450mm

Width:

30''  720mm

Ground Clearance:

5"   130mm

Wheels/Tires:

Front 12" X 6"     Rear 13" X 6"

Brakes:

Front Drum,----- Rear Electric

Speed:

1 - 0-6 KPH Fully Variable
2 - 0-4 KPH Fully Variable
3 - Reverse

Turning Circle:

12 Feet

Range:

35-50 Miles On Normal Roads
Golf – At least 26 Holes

Climbing:

35' Hills
6" Curbs

Weight:

175 LBS  [80kg] Without Batteries

Carrying Capacity:

20 stone .
And Two Full Sized Golf Bags

Chassis/Frame:

Powder Coated Tubular Steel-Galvanised

Body:

White ABS Plastic

Motor

Twin 500 watt motor gearbox driving
independently both rear wheels

 Seating

 Interior sprung fully adjustable

 EMV Sport Buggy

 Service and Maintenance.

To obtain access to the power source and batteries.

1. Remove bag support frame at back of unit. Undo and pull
   winged bolt at bottom of support. Lift support frame to unlock
   and remove.
2. Ease up canopy from the rear supports and remove
3. To remove the seat and rear panel. First loosen off knurled knob
   in front of seat [location pillar] .Lift the whole seat assemble.
   Front first and back panel off and set aside.
4. Remove the PVC cover to expose the whole power source.
5. TAKE NOTE.  Position of batteries and the connections for future reference.

 There is little or no maintenance required except to.

1.      Check batteries.

2.      All wiring connections are good and firm.

3.      Keep unit clean. If using a hose KEEP away from the electrics.

4.      Check tyre pressure. Inflate to 22-26 PSI Winter

                                                                28 PSI Summer.

5.    When reassembling if the canopy is not required the spare support bar should be fitted across the back support so that when the bag frame is fitted this will lock on the whole assembly.

 This unit was designed a duel purpose electric mobile and could be

taken on the highway. However we have fitted it out as a golf buggy

 only. It is very strong full of power and very reliable.

Will convey up to 20 stone person and 2 golf sets-Rain wear and bananas.

When replacing batteries check the height do not exceed those as fitted. [Still under warranty]

Always recharge batteries immediately after use also in wet winter conditions you will use and need more battery power.

Controls:-
The controls are easy to use, smooth and comprehensive.

Brakes. The  EMV has a twin braking system for extra safety.
As you release the power the Sport comes smoothly to a stop, even on a steep slope. In addition a hand operated twin front brakes which can be locked on for parking.

Portability:-
The EMV sport is easily transported in the boot of an estate car or a very small drive on trailer. The canopy, seat and steering are easily removed or folded for ease of use.